Vyex Digital Audio Board 7KDAB Bedienungsanleitung

7K Digital Audio Board Revision 2.0 19-Aug-2007 Vyex LLC www.vyex.com

7KDAB, Version 2.0, 19-Aug-2007  Vyex LLC, 2003-2007 5 Installing the FLASH Card The multi-media FLASH card should be inserted into the connector

7KDAB, Version 2.0, 19-Aug-2007  Vyex LLC, 2003-2007 6 Updating the 7K repeater controller firmware An EPROM containing new firmware for the 7K ha

7KDAB, Version 2.0, 19-Aug-2007  Vyex LLC, 2003-2007 7 Using the DAB LED Status indicator The DAB has a dual color surface mount LED mounted nea

7KDAB, Version 2.0, 19-Aug-2007  Vyex LLC, 2003-2007 8 Basic use In its simplest form, the DAB will mimic the original S-Com speech synthesizer bo

7KDAB, Version 2.0, 19-Aug-2007  Vyex LLC, 2003-2007 9 Supported WAV File formats For those that wish to create their own WAV files, you will nee

7KDAB, Version 2.0, 19-Aug-2007  Vyex LLC, 2003-2007 10 Recommended editing programs Adobe Audition, formally Syntrillium Software’s Cool Edit Pro

7KDAB, Version 2.0, 19-Aug-2007  Vyex LLC, 2003-2007 11 File system requirements The Multi-Media Card needs to be formatted with a DOS FAT16 file

7KDAB, Version 2.0, 19-Aug-2007  Vyex LLC, 2003-2007 12 File system structure for the Audio Files The WAV files need to be stored in a predetermin

7KDAB, Version 2.0, 19-Aug-2007  Vyex LLC, 2003-2007 13 DAB-BOOT.BIN This file contains the small bootstrap loader used to reprogram the microcont

7KDAB, Version 2.0, 19-Aug-2007  Vyex LLC, 2003-2007 14 9702 – Playback Speed Factor When this word is spoken, the word that follows it is used as

7KDAB, Version 2.0, 19-Aug-2007  Vyex LLC, 2003-2007 i INTRODUCTION 1 LIMITED HARDWARE WARRANTY 2 COPYRIGHT NOTICE AND LIMITED SOFTWARE WARRANTY

7KDAB, Version 2.0, 19-Aug-2007  Vyex LLC, 2003-2007 15 9720 – Send Serial Characters In order to allow a modem to share the same phone line that

7KDAB, Version 2.0, 19-Aug-2007  Vyex LLC, 2003-2007 16 Notice: The following special word commands were included to aid in the overall firmware

7KDAB, Version 2.0, 19-Aug-2007  Vyex LLC, 2003-2007 17 Morse Code Features Message File Location Text files containing the desired message along

7KDAB, Version 2.0, 19-Aug-2007  Vyex LLC, 2003-2007 18 Speed Two different control characters are supported for setting the speed. For normal ca

7KDAB, Version 2.0, 19-Aug-2007  Vyex LLC, 2003-2007 19 7KDAB ‘Busy’ message If the 7K attempts to command the 7KDAB to play a file while the 7KDA

7KDAB, Version 2.0, 19-Aug-2007  Vyex LLC, 2003-2007 20 Using the Serial Port Hardware Interface Connecting the DB-9 serial port connector to a PC

7KDAB, Version 2.0, 19-Aug-2007  Vyex LLC, 2003-2007 21 Connecting a Modem to the Serial Port Since every modem tends to be a bit different, it is

7KDAB, Version 2.0, 19-Aug-2007  Vyex LLC, 2003-2007 22 The Command Line Interface Using the Command Line interface (CLI) the user can effect the

7KDAB, Version 2.0, 19-Aug-2007  Vyex LLC, 2003-2007 23 DIR – Directory command While similar to the directory command under MS-DOS, this command

7KDAB, Version 2.0, 19-Aug-2007  Vyex LLC, 2003-2007 24 DEL – Delete File While similar to the delete file command under MS-DOS, this command will

7KDAB, Version 2.0, 19-Aug-2007  Vyex LLC, 2003-2007 ii 9702 – Playback Speed Factor 14 9710 – Play Random File 14 9720 – Send Serial Characters

7KDAB, Version 2.0, 19-Aug-2007  Vyex LLC, 2003-2007 25 SY – Send Y-Modem Allows a file to be sent from the DAB to the users computer via the seri

7KDAB, Version 2.0, 19-Aug-2007  Vyex LLC, 2003-2007 26 STOP – Stop current WAV file playback Immediately terminates the playback of any WAV file.

7KDAB, Version 2.0, 19-Aug-2007  Vyex LLC, 2003-2007 27 Command line interface commands available with 7K firmware 2.04 #!; - Issuing commands to t

7KDAB, Version 2.0, 19-Aug-2007  Vyex LLC, 2003-2007 28 RFP – Remote Front Panel The remote front panel command allows real time viewing of the co

7KDAB, Version 2.0, 19-Aug-2007  Vyex LLC, 2003-2007 29 “Hyperterm” users will need to visit the Hilgraeve website http://www.hilgraeve.com/ and

7KDAB, Version 2.0, 19-Aug-2007  Vyex LLC, 2003-2007 30 Firmware Update Procedure. The product firmware can be updated by placing a new firmware

7KDAB, Version 2.0, 19-Aug-2007  Vyex LLC, 2003-2007 31 Appendix A Library Contents 7K SSM Words Words 0001 through 0597 and 4097 through 4388 ar

7KDAB, Version 2.0, 19-Aug-2007  Vyex LLC, 2003-2007 32 average 1114 B 1115 back 1116 backbone 1117 backhaul 1118 backup 1119 bad 1120 baker

7KDAB, Version 2.0, 19-Aug-2007  Vyex LLC, 2003-2007 33 club 1264 Coast 1265 co-ax 1266 code 1267 coil 1268 cold 1269 college 1270 Colorado

7KDAB, Version 2.0, 19-Aug-2007  Vyex LLC, 2003-2007 34 E.T.A. 1414 Eagles_Peak 1415 earth 1416 east 1417 easy 1418 Eau_Claire 1419 echo 1420

7KDAB, Version 2.0, 19-Aug-2007  Vyex LLC, 2003-2007 iii Command line interface commands available with 7K firmware 2.04 27 #!; - Issuing commands

7KDAB, Version 2.0, 19-Aug-2007  Vyex LLC, 2003-2007 35 galley 1563 gallons 1564 gap 1565 Garden 1566 gas 1567 gate 1568 Gateway 1569 gauge

7KDAB, Version 2.0, 19-Aug-2007  Vyex LLC, 2003-2007 36 is 1712 Island 1713 isolation 1714 it 1715 Item 1716 its 1717 J 1718 Jackson 1719 Ja

7KDAB, Version 2.0, 19-Aug-2007  Vyex LLC, 2003-2007 37 midpoint 1862 Mid-Wisconsin 1863 mike 1864 mile 1865 miles 1866 Military 1867 mill 1

7KDAB, Version 2.0, 19-Aug-2007  Vyex LLC, 2003-2007 38 ouch 2012 our 2013 out 2014 outdoor 2015 outer 2016 output 2017 outside 2018 over 20

7KDAB, Version 2.0, 19-Aug-2007  Vyex LLC, 2003-2007 39 Richland 2161 Richmond 2162 Ridge 2163 rig 2164 right 2165 ring 2166 river 2167 road

7KDAB, Version 2.0, 19-Aug-2007  Vyex LLC, 2003-2007 40 station 2311 stationary 2312 status 2313 stereo 2314 stern 2315 stop 2316 storm 2317

7KDAB, Version 2.0, 19-Aug-2007  Vyex LLC, 2003-2007 41 V.H.E. 2461 V.H.F. 2462 V.O.R. 2463 V.S.W.R. 2464 Vaca 2465 vacuum 2466 Valley 2467 V

7KDAB, Version 2.0, 19-Aug-2007  Vyex LLC, 2003-2007 42 Test Tones Duration Tone dBFS 5000 2 Sec. 1kHz 0 5001 2 Sec. 1kHz -3 5002 2 Sec

7KDAB, Version 2.0, 19-Aug-2007  Vyex LLC, 2003-2007 43 Appendix B ASCII Character Chart Dec Char Name Dec Char Dec Char Dec Char 0 ^@

7KDAB, Version 2.0, 19-Aug-2007  Vyex LLC, 2003-2007 44 Appendix C – Morse Code Characters A · — J · — — — S · · · 1 · — — — — B — · · ·

7KDAB, Version 2.0, 19-Aug-2007  Vyex LLC, 2003-2007 iv {PW} 76 ff yyyy (zzzz) IF-THEN-ELSE 49 New Switches 50 {PW} 63 16 x Daylight Savings

7KDAB, Version 2.0, 19-Aug-2007  Vyex LLC, 2003-2007 45 Appendix D Version History Product Firmware Revisions Product firmware revision history is

7KDAB, Version 2.0, 19-Aug-2007  Vyex LLC, 2003-2007 46 Appendix E 7K Version 2.04 Release Notes Disclaimer While this software is derived from

7KDAB, Version 2.0, 19-Aug-2007  Vyex LLC, 2003-2007 47 New Commands {PW} 16 Stop playback of current speech word Issuing this command will

7KDAB, Version 2.0, 19-Aug-2007  Vyex LLC, 2003-2007 48 {PW} 49 90/91/92/93 xx Message Handler Initial Message Delay Timer’s 90 through 93 now al

7KDAB, Version 2.0, 19-Aug-2007  Vyex LLC, 2003-2007 49 {PW} 76 ff yyyy (zzzz) IF-THEN-ELSE ‘ff’ is the feature to be tested ‘yyyy’ is the ma

7KDAB, Version 2.0, 19-Aug-2007  Vyex LLC, 2003-2007 50 New Switches {PW} 63 16 x Daylight Savings time correction This switch defaults to ‘o

7KDAB, Version 2.0, 19-Aug-2007  Vyex LLC, 2003-2007 51 {PW} 63 92 x User Soft Switch 1 {PW} 63 93 x User Soft Switch 2 {PW} 63 94 x Us

7KDAB, Version 2.0, 19-Aug-2007  Vyex LLC, 2003-2007 52 Changed Commands {PW} 02 f … CTCSS Encoder Function code ‘f’ Description 0 CTCSS

7KDAB, Version 2.0, 19-Aug-2007  Vyex LLC, 2003-2007 53 {PW} 40 r xxx Set Transmit Timeout Timers The new ‘r’, receiver, parameter allows the u

7KDAB, Version 2.0, 19-Aug-2007  Vyex LLC, 2003-2007 54 New Message Types Four new message types were added to support interruptible speech and Mo

7KDAB, Version 2.0, 19-Aug-2007  Vyex LLC, 2003-2007 1 Introduction Thank you for purchasing the 7K Digital Audio Board (DAB). The DAB has been d

7KDAB, Version 2.0, 19-Aug-2007  Vyex LLC, 2003-2007 55 Bug Fixes and Changes Version 2.04 Special Messages 9860 through 9895 will no longer caus

7KDAB, Version 2.0, 19-Aug-2007  Vyex LLC, 2003-2007 56 Version 2.04f • Fixed a problem introduced in version 2.04a related to being able to queu

7KDAB, Version 2.0, 19-Aug-2007  Vyex LLC, 2003-2007 57 Appendix F Schematics Revision F

7KDAB, Version 2.0, 19-Aug-2007  Vyex LLC, 2003-2007 58 Revision E

7KDAB, Version 2.0, 19-Aug-2007  Vyex LLC, 2003-2007 59 Revision D1

7KDAB, Version 2.0, 19-Aug-2007  Vyex LLC, 2003-2007 60 Daughter board used with Digital Audio Boards prior to revision “E”, to correct speech bus

7KDAB, Version 2.0, 19-Aug-2007  Vyex LLC, 2003-2007 61 Appendix G – Daughter PCB Installation The daughter board must be used in conjunction

7KDAB, Version 2.0, 19-Aug-2007  Vyex LLC, 2003-2007 2 Limited Hardware Warranty Vyex LLC warrants that its products will be free from defects in

7KDAB, Version 2.0, 19-Aug-2007  Vyex LLC, 2003-2007 3 In no event shall Vyex LLC or its suppliers be liable for any damages whatsoever (including,

7KDAB, Version 2.0, 19-Aug-2007  Vyex LLC, 2003-2007 4 Installation CAUTION: The DAB is a static sensitive electronic device. Proper precautions